SPRAY ADHESIVE QS 900 is a fast tacking - non-chlorinated spray adhesive. This specialist formulation will provide instant grab which allows pressure to be exerted on the bond before full cure strength is achieved.
ADVANTAGES
- Quick stick - provides instant grab
- Provides permanent bonds
- Free from chlorinated solvents
- Tack time approximately 30 seconds
- Economical in use - only a light film is required for instant grab
APPLICATIONS
QS 900 Quick Stick Adhesive has been formulated to satisfy the demands of the carpeting and flooring trade. It is also suitable for bonding many different substrates including:
- Carpet
- Underlay
- Foam
- Fabric
- Cork
- Upholstery
- Paper
- Cardboard
- Wood
Apply a light - fine even coating to both surfaces to be bonded from 9 -12 inches (25 - 30 cm). Wait until the adhesive is tack-dry and bond the surfaces together using firm pressure. Heavier applications of QS 900 may prolong the tack time. N.B. May affect certain plastics.Always test a small - inconspicuous area before general use. To prevent blockages invert the can after use and spray to clear the nozzle.
SPECIFICATIONS
- Appearance : Clear - amber liquid
- Odour : Characteristic Solvent
- SG @ 25°C : 0.66
- Pressure @ 25°C : 4 Bar
- Discharge rate : 1.2 g/sec
- Polymer type : Styrene Butadiene Rubber
- Tack time : Approximately 30 seconds
- Bonding time : Maximum adhesion in 12/24 hours
- Temperature range : Up to 50°C (dried film)
- Solubility : Soluble in some solvents insoluble in water
- Flammability : Classified as extremely flammable under CHIP Regulations
- Packaging : 500ml aerosol
STORAGE
The product may be stored at normal ambient temperatures and has a shelf life of not less than 36 months with correct storage. Aerosols should always be stored below 50°C - away from direct heat and naked flame.